Cpi gtr service manual. CPI service manuals for download, free! 2019-01-25

Cpi gtr service manual Rating: 6,8/10 1709 reviews

Reading : Cpi Gtr 150 Repair Manual

cpi gtr service manual

Disconnect the wires of A. Remove the idle gear plate. Please have a protected pad on the proper location of the ground to avoid crash or damage of plastic parts. Install the oil seal into the right crankcase. Loose the screw of the air cleaner band. Grease the shaft seal prior to mounting. Remove the throttle valve from the carburetor.

Next

CPI service manuals for download, free!

cpi gtr service manual

Standard value: 15 mm Measure the height of the roller weight. Remove the throttle control cable. Install the crankshaft bearing into the right crankcase. For the front fork ii. Install the crankshaft into the left crankcase.

Next

CPI ARAGON SERVICE MANUAL Pdf Download.

cpi gtr service manual

Coat the cylinder and piston ring with the engine oil. Electric component parts built in the microcomputer or relay are sensitive to heat and can easily get damaged. Disconnect the rear brake cable. Pay attention not to chock the shaft seal. Remove the throttle valve from the carburetor. Disconnect the spark plug cap.

Next

CPI service manuals for download, free!

cpi gtr service manual

Remove the fly wheel by using a pulley. Clean the grooves for carbon deposit completely. Remove the bearing of crankcase by using a bearing pulley. Loose the carburetor cap of throttle valve. Measure the width of the V-belt upper and lower side. Remove the right crankcase from the left crankcase by using a pulley. Remove the setting bolt of oil pump.

Next

CPI GTR Service Manual

cpi gtr service manual

Remove the setting bolt of engine. Remove the carburetor and the air filter body. Set the tester to ignition test, dial out the electrodes and observe the spark gap. Remove the setting bolt of rear cushion. Use Loctite® 518 sealing compound only! Measure the lateral runout with the aid of two dial gauges. Remove the right crankcase from the left crankcase by using a pulley.

Next

CPI ARAGON SERVICE MANUAL Pdf Download.

cpi gtr service manual

Check the individual clutch shoes for free movement. Remove the rear luggage case. Mileages are expressed in terms of kilometers and months. Separate the rightcrankcase half from the left one with a suitable puller. Open and remove the seat. Measure the diameter of the guide sleeve. The allowable adjustment track to the full throttle position must be at least 70°.

Next

CPI GTR Service Manual

cpi gtr service manual

Install the crankshaft into the left crankcase. Let the oil drain out in smoothly then tight the screw. P All ring should be installed with the mark facing up. The latching clips are properly locked in place when you can hear a click noise. Connect the charge negative - cable to the battery negative - terminal. Remove the kick pinion with the kick friction spring. Mark connections with an ohmmeter as shown.

Next

Cpi Gtr50 Scooter Workshop Repair Manual PrintablePDF 2019 PDF Book

cpi gtr service manual

Remove the kick spindle bush. Adjust the rear brake free play. Disconnect the earth wire of engine. Disconnect the starter plunger wire. Remove the setting nut of driver face. Remove the setting bolts of cylinder head.

Next

CPI GTR 50 SERVICE MANUAL Pdf Download.

cpi gtr service manual

Mileages are expressed in terms of kilometers and months. Remove the setting nut of driver face. In case of any defects in this part, the float shall be replaced. Remove the crankcase from the left crankcase by using a pulley. Remove the throttle valve from the carburetor.

Next

CPI ARAGON SERVICE MANUAL Pdf Download.

cpi gtr service manual

To avoid slack, wiring harnesses have to be fixed with cable clamps or cable fastening ribbons. Loosen the impeller screws and remove the impeller. Use a new sealing ring prior to mounting the float chamber cover. Remove the setting bolt of engine. Remove the kick pinion with the kick friction spring. Remove the bearing of crankcase by using a bearing pulley. Disconnect the rear brake cable.

Next